Fill and Base Material Delivered in New Carlisle, IN

Indiana Rock Supply handles gravel and aggregate delivery in New Carlisle, IN. The base most jobs here start with is #53 stone, a dense graded crushed limestone that packs hard under drives, pads and slabs. New Carlisle sits in the Michiana moraine country, where low spots hold water and a thin base shows it fast.

If your grade is low or your building pad is soft, the load you need first is fill, not stone. We stock both, so you can build up the grade and cap it in the same order.

Materials for New Carlisle Projects

Most work here starts below the surface. Fill dirt, also called fill, raises grade, fills low spots and backfills before any base goes down. Spread it, compact it, then cap it with #53 stone. That is the standard Indiana base.

For a tighter surface on a drive or parking pad, top the compacted base with #73 stone. It is finer than #53 with a smaller top size, so it packs smooth. Indiana suppliers usually call the surfacing layer driveway stone.

Under pavers and flagstone, bedding is a separate job from base. Use stone screenings to level the surface and set the units. Around a patio or a downspout line, drain rock handles the water that would otherwise sit against the house.

For concrete work, 3/4 inch crushed stone and #57 stone are the usual clean stone choices. Both drain well and lock together under a slab.

Ground and Conditions in New Carlisle

This part of St. Joseph County is rolling moraine ridges of loamy to clayey glacial till, broken by sandy and gravelly outwash plains. Kettle lakes, bogs and pockets of muck and peat sit in the low spots. That mix decides how deep your base has to be.

Water soaks away fast through the outwash sand and gravel. On the denser till it perches instead, and it collects in kettle depressions, muck pockets and the low ground around the lakes. A driveway built over that till with a thin base will pump and rut the first wet spring.

Soft ground here needs a deeper base and a way for water to drain. Cut out the soft material, build back with fill, compact it in lifts, then cap with #53 stone. Where water has nowhere to go, add a drainage layer of clean stone so it has somewhere to move. Heavy rain also gullies bare slopes on the moraines and cuts into stream banks and lakeside soils, so bare ground wants cover sooner rather than later.

Timing matters as much as material. Base and driveway work runs best from late spring, once the till and the low spots dry out, through fall. Frozen ground stops compaction through winter, so a winter base is money spent on material that will not lock up.

Frost is the other factor. Cold winters with repeated freeze-thaw heave gravel drives and soften till subgrades each spring. This area has among the deeper frost depths in Indiana. The exact footing depth is set by the county or city building department, so confirm it before you pour.

Delivery to New Carlisle and the Surrounding Area

Order online and pick your quantity by the ton or the yard. Work out the area you are covering and the depth you want, and the site will size the load. If you are building up a low spot, measure the depth of fill you need first. Fill and base are two separate loads, and ordering them together saves a trip.

Bulk delivery drops the material where the truck can reach. Point us to the spot on the order so it lands where you want to spread it, not where you have to move it twice. We also run material to South Bend, Mishawaka, Granger, Osceola and Walkerton in St. Joseph County.

Questions About Base and Fill in New Carlisle

What is the best base under pavers in New Carlisle?

Compacted #53 stone is the standard base under pavers here. It is a dense graded crushed limestone with fines that packs hard. Build it in lifts, compact each one, then bed the pavers in stone screenings. On soft till or muck, cut out the bad material and bring the grade up with fill before the #53 goes down.

Do you supply contractors working in New Carlisle?

Yes. Builders, excavators and landscapers working in New Carlisle and the rest of St. Joseph County order fill, base stone, clean stone and sand through the same online checkout. You can size loads by the ton or the yard and have them dropped at the site. Multiple loads for one job can be ordered together.

Order Fill and #53 Stone for Your New Carlisle Project

Start with the grade. Bring low ground up with fill, compact it, then cap it with #53 stone, the base this market builds on. Add #73 stone or clean stone where the job calls for it. Order online and have it delivered to your site in New Carlisle.